Abstract
Prevention and treatment of total joint infection is closely related to biofilm formation and concentration of antibiotics achieved in the area around the implants. Most total joint infections are caused by bacteria that enter the wound at the time of the operation. These bacteria can attach to surfaces and rapidly form biofilm that is highly resistant to antibiotics. Prophylactic antibiotics given intravenously achieve concentration of local antibiotics in the knee in response to intravenous antibiotics about 1/3 of that achieved in the serum, and the level is transient. This may be enough to treat the planktonic form of the bacteria, but far from enough to treat the biofilm. The concentration of antibiotics in the joint fluid achieved with antibiotics applied locally during surgery is 1000 times higher, and can be maintained throughout the procedure. High concentration persists in drainage fluid for 24 hours after surgery. Studies done with use of local antibiotics in spinal implant surgery indicate a major reduction in the rate of infection, and cost analysis shows remarkable monetary benefit to this effect.
Infected total joints benefit especially from direct application of antibiotics to the local area. The safety and efficacy of this protocol was evaluated in patients undergoing primary or revision TKA by measuring joint and serum levels of vancomycin following IV administration (as a prophylactic) and IA administration (as a treatment for infected TKA), and comparing the levels with each method. Therapeutic levels of vancomycin were present in the knee following IV or IA administration, but much higher levels were possible with IA administration (avg. of 6.8 and 9,242 µg/mL). Vancomycin achieved therapeutic levels in the synovial fluid of the knee with IV administration, but clearance from the knee was rapid, suggesting that the synovial fluid concentration may be sub-therapeutic for hours before the next IV dose is given. In contrast, IA delivery of vancomycin resulted in peak levels that were thousands of times higher, and trough levels remained therapeutic for 24 hours in both the joint space and in the serum (minimum trough levels of 8.4 and 4.2 µg/mL, respectively). The elimination constant (half-life) of IA-administered vancomycin was 3.1 hours.
Directly infusing antibiotics into the infected area maintains a high local concentration level while minimizing systemic toxicity. This method avoids the use of antibiotic-loaded cement and the potential for growth of antibiotic-resistant strains of bacteria. These findings support single-stage revision in cases treated with cementless revision and IA antibiotics.
Preventing and treating infection in orthopaedic implant surgery requires achieving concentrations that are above the minimal biofilm eradication concentration. This can be achieved only with direct application.
